Project consists of roof replacement at Fleet Management, Charlotte, North Carolina. This work includes
the provision of labor, material, equipment, supervision and administration to includes:
1. Roof Areas A, B, C and D:
a. Complete removal of all existing metal roof, insulation, bituminous flashings and metal flashings,
gutters and downspouts, abandoned vents and discard.
b. Furnish and install new roof insulation, structural metal roof panels and all associated
miscellaneous work as specified herein.
c. Furnish and install new gutters, downspouts and bituminous and metal flashings.
2. Roof Area E:
a. Furnish and install new roof insulation, fully adhered PVC roof membrane and all associated
miscellaneous work as specified herein.
b. Furnish and install new gutters, downspouts and bituminous and metal flashings.
Phase II Animal Care & Control renovations will address non-compliant issues per the NC Department of Agriculture and Consumer Services, Animal Welfare Section (NCDA&CS) Inspection reports issued in 2018, 2020, and 2021. Phase II will address renovations for separation of species, inadequate ventilation surfaces not impervious to moisture, slab repair, additional square footage for dog and cat housing, and if funding is available fencing and gate replacement for dog kennels. This phase also will address ADA Barrier renovations to meet international ADA code requirements.
The facility is located at 8315 Byrum Drive, near the airport. This facility is just under 30 years old and the renovations required are a direct response to the NCDA&CS inspection reports. Also, the project will incorporate renovations to address ADA barriers in the facility, such as door hardware, signs, plumbing, minor parking lot curbing, etc.
CMPD background checks will be required for all construction staff, vendors, and anyone occupying the site during construction and deliveries.
This contract will be to provide roof and sealant replacement on the building at
4824 West Boulevard for Charlotte Douglas International Airport, Charlotte, North Carolina. This will be a complete removal of existing roofing membrane, insulation, flashings, sheet metal flashings, gutters, and downspouts, and complete removal of all existing backer rod and sealant at exterior wall brick control joints; repair and/or replacement of rusted and/or deteriorated metal deck, and the installation of new insulation, cover board, mechanically fastened 60 mil TPO membrane and associated flashings, sheet metal flashings, gutters and downspouts, and backer rod and sealant at exterior wall brick control joints and all associated miscellaneous work. The contractor must also provide temporary protection of contents in the building and cleanup of debris associated with removals. The roof has exceeded the expected lifespan and is currently 30+ years old. The project term will be 180 days.
- WORK COVERED BY CONTRACT DOCUMENTS
- Project Identification: The project consists of roof recover at the Charlotte Area Transit System (CATS) Light Rail Administration Facility, 3200 South Boulevard, Charlotte, North Carolina.
- Project Access: Access to the facility is at 3305 Pelton Street, Charlotte, North Carolina located at the rear of the facility.
- Base Bid: Work is generally as follows:
- Removal of lightning protection system and storage for reuse.
- Removal and disposal of all existing single-ply membrane and flashings; metal flashings, scupper liners and coping caps; installation of new polyisocyanurate roof insulation, gypsum cover board and overlay, fleeceback Polyvinyl-Chloride (PVC) roof membrane and flashings, wood blocking, metal flashings, coping caps, PVC scupper liners and all associated miscellaneous work as specified herein.
- Complete removal of existing brick along wall above roof level at Area D; and installation of new through-wall flashing and brick replacement consisting of use of salvaged brick if in good condition and providing new brick (to match existing) as required.
- Reinstallation of lightning protection system upon completion of the roofing work according to specifications and requirements of the original UL master label installation.
The existing roof systems from top to bottom are as follows:
||Areas A, B, C and D
||Fully adhered Hypalon-based single-ply membrane
||1/2 inch gypsum fiber roof board
||Two (2) layers of 2-inch extruded polystyrene (XPS)
||5/8 inch gypsum fiber roof board
||Metal deck except that parts of Area A has acoustical metal deck
||Internal roof drains with overflow scuppers
||1/4 inch per foot structural slope with XPS insulation drainage crickets
Approx. heights of roofs to top of parapets above grade is 50 feet.
Approx.. square footage of roof project is 18,313 sq.ft.
Roofing Replacement of various Wastewater Treatment Plants’ structures: McDowell, Irwin, Sugar Creek and McAlpine. Replacement consists of complete tear off of existing roof down to substrate. Minor mechanical and electrical relocation/replacement work will be performed, if necessary.
Roofing Replacement of various Water Treatment Plants and Water Booster Station structures. Replacement includes complete tear-off of the existing roof down to the substrate. Minor mechanical and electrical relocations and re-hook-ups are required.
This project consists of replacing various roofs at the McDowell Creek Wastewater Treatment Plant. This package will potentially include the replacement of four separate roofs.
Charlotte Douglas International Airport (CDIA) has responsibility for maintenance and repair of approximately one hundred (100) buildings including the airport terminal. CDIA requires a minimum of two on-call contractors to perform repairs, replacement and emergency roof repairs of these facilities.
The selected contractors will enter into a time and materials contract for on-call roof replacement and repair services on an as needed basis. The contract will include a three (3) base years and two (2) optional one-year (I) terms for a total potential contract period of five (5) years. The work shall include the furnishing of all supervision, labor, materials, and services required to make the necessary repairs. Along with making repairs to roofs, the contractors shall be required to demolish and remove existing roof materials and dispose of all waste material. Repairs shall be billed on an agreed upon hourly rate and percent mark-up on materials.
The Vest WTP’s Clearwell No. 3 existing precast concrete panels which already had its existing TPO Membrane roof demolished will be replaced with a new FRP Deck and TPO Membrane roof.